Publications Main Page
FAQs Main Page
Horse Trailer Maintenance and Trailering Safety
Marjorie R. Margentino, Former Program Associate in Animal Science; Karyn
Malinowski, Ph.D., Director of the Equine Science Center; Carey A. Williams, Ph.D.,
Extension Specialist in Equine Management; Sara R. Malone, Department of Animal
Revised July 2007
Fact Sheet #607
Horse owners will usually find it necessary at some point in time to trailer their
horses. Trailering may be necessary at time of purchase, for horse
shows, trail riding, or a medical emergency. Whatever the need, it is
important to be prepared and knowledgeable about trailering safety.
Poor preparation of the horse, trailer or towing vehicle can turn a
pleasurable outing into a horse owner’s nightmare. Poor truck and
trailer maintenance can result in traffic accidents or breakdowns. In
more extreme cases, broken welds can cause a trailer to become
detached from the towing vehicle. Perhaps the most serious problem
that can result from improper trailer upkeep is having a horse fall
through rotted floorboards, especially during travel. This fact sheet will
discuss the basic concerns involved in horse trailer maintenance and
When purchasing a horse trailer, consider the following needs:
Regular maintenance checks should be performed on a horse
trailer every time it is used. Routine items include:
- First, when selecting a towing vehicle, it is important to make sure that
the weight of the trailer and load (horses) does not exceed that of the
towing vehicle. Smaller pulling vehicles, like sport utility vehicles, have the
power to “pull” the load but not to stop it, and often end up jack-knifed or
in a ditch when the trailer pushes them down the road.
- Ample height (7-8 feet) and width (6-8 feet) for the horse(s)
- Rubber mats on the floor and the loading ramp to provide
traction and cushion during loading, unloading and travel.
- Tie ropes or chains of adequate length with quick release safety
- Adequate padding on chest bar and stall sides.
- Interior lights for night time hauling.
- Air vents on the roof and along side panels.
Yearly maintenance checks include:
- Tires need a minimum amount of 1/4" of tread (check with your
state Division of Motor Vehicles for the measurement); they
should be adequately inflated and have no signs of dry rot
cracks. Spare tires also should be checked.
- Jacks and safety triangles or reflectors should be in good
working order in case of breakdown. (Ignitable flares should not
be stored in the horse trailer because of fire potential).
- Floorboards should not be rotted or in weak condition. Replace
any boards that are questionable. To help lengthen the life of a
trailer floor, mats should be lifted after use and the floor swept
or hosed out. If the floor is hosed, be sure it is dry before the mats
are replaced. Yearly applications of a weather sealer on the floorboards
will also extend their life.
- Screws, bolts or nails that may have worked loose and are
protruding from the inside of the trailer should be removed.
- All lights (marker, tail, brake, directional and interior) should be
working and bright.
- Hitch welds, safety chain welds and snaps should be in good
- Hitch ball should be kept greased as needed.
- Wheel chocks should be in good condition. Use them any time
the trailer is unhitched from the towing vehicle.
Preparing the Horse for Travel
- Inspection of frame for cracks, and wires for loose connections
and frayed covering.
- Repair or replacement of rotted or rusted metal.
- Greasing of all hinges, springs, etc.
- Inspection of ramp hinges and springs for weakness and cracks
- Wheels should be pulled and bearings checked and repacked.
- Inspection of spring shackles for wear.
- Inspection of brakes and emergency break-away cable, pin and control box.
- Practice loading and unloading the horse in the trailer well in
advance of any scheduled events, especially if the horse is
unfamiliar with trailering. A battle getting into the trailer is an
unpleasant way to start a journey or end what has been an
enjoyable day. Recent research has shown that horses that
undergo training to load may have a decreased load time and
decreased stress response to loading.
- Horses should be trailered in a leather halter, or nylon halter
with a breakaway piece. In an emergency situation (such as the
halter becoming snagged) a leather halter will break more easily
and is less likely to injure or burn the horse’s head.
- There are many options for protecting the horse’s legs during
travel. If legwraps are worn, it is important that the wraps are
applied properly for the style and type of wrap.
- Always remove all tack (saddle, bridle, harness) from the horse
- If the trailer is a stock trailer or has open vents, wet or clipped
horses should be blanketed.
Considerations Before Traveling
- Horses traveling across state lines require a recent health
certificate and may require proof of certain vaccinations
depending on destination. Check with your veterinarian or the
state veterinarian in your jurisdiction for more information on
the exact health requirements for traveling with your horse.
- In New Jersey, all horses which are traveling must have a recent (within
one year) negative Coggins test.
- If you are planning on staying overnight with your horse while
traveling, a list of overnight stables is available in the Nationwide
Overnight Stabling Directory and Equestrian Vacation Guide
- Horses traveling in a trailer for more then 24 hours show a body
weight loss of 6% and they only regain 3% of that body weight after a 24 hour recovery time. So special considerations
should be made for horses traveling long distances. Water should be
provided and adequate recovery time should be allowed after
Loading the Horse
- Make sure that the trailer is securely and properly hitched to the
towing vehicle before loading a horse. Never load a horse or
leave a horse in an unhitched trailer. Do not unhitch a
trailer with a horse still inside. Trailers are very unstable and can
easily tip on end.
- Whenever loading or unloading horses, it is best if
two people are available to do the job.
- Use a cotton lead rope or leather lead when loading
or unloading horses, and wear a pair of gloves. This is advisable in the
event that the horse rushes backwards, pulling the lead through
your hands. Nylon leads will blister, burn and cut hands when
- Before walking a horse into the trailer, make sure
that chest bars and escape doors are open for the handler to exit
- Never climb under or over dividers, chest bars or the
horse to exit the trailer. Never leave yourself in the position of
being trapped in the trailer with the horse between you and the
- When loading a single horse, place the horse on the
left side of the trailer. When trailering two horses, place the heavier
horse on the left side. This will make towing the trailer smoother
and the ride easier for the horse because of the crown contour of the
- When approaching the ramp make sure the horse is in
the center of the ramp so that the horse does not step off the sides.
- Always secure the butt bar/chain before tying the
horse’s head. If the horse is tied and pulls back before the butt
bar is in place it runs the risk of breaking the tie or
halter and falling down. Do not stand directly behind the horse
when hooking the butt bar in case the horse runs
- When tying the horse’s head use a
safety-quick-release knot or a tie with a panic safety snap (See Fig. 1). Make sure the
horse has enough rope length to permit head movement for balance,
but not to get its head down or over to the horse traveling
Unloading the Horse
- Most horses take to trailering naturally, while for
others it is often a traumatic experience. It is important that a horse be
happy and secure when being trailered. One bad experience in
trailering is all it takes to make a horse a bad hauler. A
bad hauler is hard to cure.
- Before traveling, check to see that the horse is
comfortable and that ventilation is adequate. The hay bag or manger should be
securely fastened so that the horse cannot become tangled in it.
- Test all doors to make sure they are secure, and
check that the hitch is tight. Safety chains should be in place and all
lights and brakes should be functioning in accordance with your state’s
Division of Motor Vehicles codes.
- Turns, starts and stops should be very slow and steady.
- Do not exceed the speed limit. Remember to allow extra
stopping distance when towing a trailer. Moving horses and the
weight of the trailer will push against the towing vehicle.
- Do not allow anyone to throw lit cigarettes or matches from the
window of the towing vehicle. Wind currents often suck the cigarettes or matches into the trailer, causing a fire.
- Check on the horse(s) at every stop or every 100
miles. At this time also check the hitch, safety chains, lights and hay bags. Keep hay
bags full and offer the horse(s) a drink of water.
- Avoid backing up with the trailer if at all possible.
If backing up is necessary it is advisable to have a person outside the
vehicle to watch and guide you.
Other Safety Precautions
- When lowering the ramp, keep feet and hands out of the way.
- Untie the horse before lowering the butt bar.
- Do not stand on the ramp or directly behind the trailer when a
horse is exiting in case it leaves the trailer quickly. It is not
advisable to allow a horse to fly back quickly as this soon becomes a bad and dangerous habit.
- Try to keep the horse straight as it backs down the
ramp so that it does not step off the side. Walk the horse around after
trailering for an extended distance to restore circulation and
ease stiff muscles.
Trailering your horse is often a necessity and should be an uneventful
experience. As long as common sense is used and the safety
guidelines above are followed, trailering accidents are less likely to
- The ramp to the trailer should be in an up position when tying a
horse to the outside of the trailer, especially when the tie rings
are located towards the rear. A ramp in the down position leaves
space between the back of the trailer and the springs where a
horse can easily get a foot or leg stuck. The ramp is alsothe
right height for the horse to injure its lower legs on.
- Never leave a horse tied to the outside of a trailer
unattended. When leaving a horse inside a trailer, make
sure the chest bar and butt bar are secure, especially if
an escape door is left open.
- Are the trailer and horse roadworthy. October 2003. Miller, R.
- Basic Horse Safety Manual. American Youth Horse Council in
Cooperation with the American Horse Council. 1989.
- Dehydration, stress, and water consumption of horses during
long-distance commercial transport. 2000. Friend, T. Journal of
- Nationwide Overnight Stabling Directory and Equestrian Vacation
Guide. 2006. Equine Travelers of America, Inc.
- Trailer Loading Stress in Horses: Behavioral and Physiological
Effects of Nonaversive Training (TTEAM). 2003. Shanahan, S. Journal
of Applied Animal Welfare Science.
- Trailer Safety Checklist. May 1990. Hayes, K. Equus Magazine,
- Physiological responses of horses to 24 hours of transportation
using a commercial van during summer conditions. 2000. Stull, C. and
A. Rodiek. Journal of Animal Science.
This publication was made possible in part by a grant from the
National Institute for Occupational Safety and Health Program on Agricultural Health
Promotion Systems for New Jersey.
© 2007 by Rutgers Cooperative Extension, NJAES, Rutgers, The State
University of New Jersey.
Desktop publishing by Rutgers Department of Communications. Revised:
Figure 1. Quick release knot.